Biogas-driven complete nitrogen removal from wastewater generated in side-stream partial nitritation.

Anaerobic digestion is an attractive process in wastewater treatment plants (WWTPs) to achieve simultaneous sludge reduction and energy recovery. While converting the majority of organic carbon to biogas (mainly consisting 60%CH4 + 40%CO2), the high-strength anaerobic digestion liquor consists of a high level of nitrogen concentration. The feasibility of utilizing biogas produced in-situ to achieve satisfactory nitrogen removal performance from partially nitrified anaerobic digestion liquor was examined in this study. To this end, a membrane biofilm reactor (MBfR) was used to couple nitrite- or nitrate-dependent anaerobic methane oxidation (n-DAMO) and anammox microorganisms, which was supplied with synthetic biogas and partially nitrified anaerobic digestion liquor (470 mg NH4+-N/L + 560 mg NO2--N/L). The MBfR achieved not only nearly complete nitrogen removal (~99%), but also a practically useful nitrogen removal rate above 1 kg N/m3/d. Due to the acidification caused by excessive CO2 supply from biogas, pH dropping was observed. Two corresponding strategies, i.e., intermittent alkali dosing and intermittent nitrogen gas flushing, were developed to control the pH at neutral. Mass balance based on batch tests and microbial community analysis by 16S rRNA gene amplicon sequencing both showed the joint contribution of anammox bacteria and anaerobic methane oxidizers to the nitrogen removal. This study proved the potential and capacity of MBfR to access complete nitrogen removal from high-strength wastewater by using biogas produced in-situ, thus leading to a significant reduction of external carbon addition in practice.