Effectiveness of substantial shortening of the endotracheal tube for decreasing airway resistance and increasing tidal volume during pressure-controlled ventilation in pediatric patients: a prospective observational study.

The endotracheal tubes (ETTs) used for children have a smaller inner diameter. Accordingly, the resistance across ETT (RETT) is higher. Theoretically, shortening the ETTs can decrease total airway resistance (Rtotal), because Rtotal is sum of RETT and patient's airway resistance. However, the effectiveness of ETT shortening for mechanical ventilation in the clinical setting has not been reported. We assessed the effectiveness of shortening a cuffed ETT for decreasing Rtotal, and increasing tidal volume (TV), and estimated the RETT/Rtotal ratio in children. In anesthetized children in a constant pressure-controlled ventilation setting, Rtotal and TV were measured with a pneumotachometer before and after shortening a cuffed ETT. In a laboratory experiment, the pressure gradient across the original length, shortened length, and the slip joint alone of the ETT were measured. We then determined the RETT/Rtotal ratio using the above results. The clinical study included 22 children. The median ETT percent shortening was 21.7%. Median Rtotal was decreased from 26 to 24 cmH2O/L/s, and median TV was increased by 6% after ETT shortening. The laboratory experiment showed that ETT length and the pressure gradient across ETT are linearly related under a certain flow rate, and approximately 40% of the pressure gradient across the ETT at its original length was generated by the slip joint. Median RETT/Rtotal ratio were calculated as 0.69. The effectiveness of ETT shortening on Rtotal and TV was very limited, because the resistance of the slip joint was very large.